gecopieërd van Swedespeed forum:
IMPORTANT RECALL NOTICE
May 25, 2007
To all Volvo Retailers and Employees:
RE: Recall 181, certain model year(s) 2003-2004 S60/V70 Fuel Pressure Sensors
Volvo Cars of North America, LLC (Volvo) has notified the National Highway Traffic Safety
Administration and Transport Canada that we will perform a Voluntary Safety Recall to replace
the Fuel Pressure Sensor on certain model year 2003 and 2004 Volvo S60/V70 vehicles.
The fuel pressure sensor (FPS) located on the left side of the fuel rail, may at times transmit
incorrect signals regarding the fuel pressure to the Engine Control Module (ECM). If the signal is
outside of the pre-programmed allowable limits, a Diagnostic Trouble Code (DTC) may be set
and the Check Engine Light (CEL) will come on.
Engine misfire may occur during driving that in turn can reduce the engine torque, in the worst
case scenario the engine may stall without warning.
Detail See:
http://ss.otheron.com/rkelly/video/R...er+-+FINAL.pdf
NOTE: ENGINE CODE 52 is the R engine
"Reference Bulletin SMB 23-181, TNN 23-181
Volvo Cars of North America, LLC and Volvo Cars of Canada Corp. have announced a Recall Campaign affecting certain 2003-2004 S60, V70.
It has been decided that a defect related to motor vehicle safety exists in the fuel pressure sensor of certain model 2003-2004 S60 and V70 vehicles.
The corrective action will be to replace the fuel pressure sensor with a part of a modified design.
Approximately 48,300 vehicles in the US and 4,100 vehicles in Canada are affected.
The following part number applies:
Part Number Description Qty
983706 Cable Tie 1
30756097 Pressure Sensor, Turbo 1
8699448 or replacing 30756098 Pressure Sensor, Non-Turbo 1"
More:
"Engine code 52 and 59 (turbo engines), the fuel pressure sensor may at times transmit an incorrect signal to the Engine Control Module (ECM). If the signal value is outside the allowed limits, Diagnostic Trouble Codes (DTCs) ECM-2600, ECM-2100, ECM-211A, ECM-260A or ECM-261A may be stored and the Check Engine Light (CEL) lit. This defect may cause misfire during driving, resulting in reduced engine torque. In the worst case scenario, the engine may stall without warning. In certain traffic conditions this could cause an unsafe situation and possibly a crash."
This is:
Parts Bulletin Group 23, Number 181
Service Managers Bulletin Group 23, Number 181
Tech Net Note Group 23 Number 181
Cars affected by this recall:
"S60, V70 with engine code 52, 59, 61, 64
The engine code is the 6th and 7th digits of your VIN.
M. YEAR: 2003 – 2004
CHASSIS:
S60 235112 – 372809
V70 286155 – 404037
NOTE: NOT ALL VEHICLES WITHIN THE CHASSIS LIMITATIONS ABOVE ARE AFFECTED. RETAILER MUST CONFIRM VEHICLE ELIGIBILITY IN VRC2 PRIOR TO BEGINING RECALL REPAIRS"
Misschien kan je hier wat mee?
